3 interconnect solutions http://www.3m.com/interconnects/ 3m is a trademark of 3m company. for technical, sales or ordering information call 800-225-5373 3m ? round, shielded/jacketed, disc. wire cable 28 awg stranded, twisted pair, po/pvc 3644x series ? dual shielding provides 35 db average shielding effectiveness ? wires are color coded for easy identifcation ? meets external wiring requirements of national electrical code, article 725 (cl2) ? ul listed for us and canadian markets ? please contact your 3m sales representative for variations not described in this specifcation. ? see regulatory information appendix (ria) for chemical compliance information (ria e1 & c1 apply) date modifed: may 13, 2009 ts-0826-b sheet 1 of 3 physical jacket material: polyvinyl chloride (pvc) color: beige primary material: polyolefn (po) marking : standard: (ul) cl2 75c 30 awg 3m xx c awm iia/b 80c 150v ft1 eu <50v (where xx may be nu or nw) conductors: 28 awg 7 36 [ 7 0.127 ] tinned stranded copper shielding: 0.001 [ 0.03 ] thick aluminum/polyester film foil and 90% coverage tinned copper braid electrical voltage rating: usa: n.e.c. 725 cl2 canada: 150v eu: <50v insulation resistance: (primary cable) > 1 10 10 /10 ft. [ 3 m ] characteristic impedance: unbalanced balanced 63 100 capacitance: 24.2 pf/ft [ 79.4 pf/m ] 15.3 pf/ft [ 50.2 pf/m ] inductance: 0.10 h/ft [ 0.33 h/m ] 0.15 h/ft [ 0.49 h/m ] propagation delay: 1.54 ns/ft [ 5.05 ns/m ] 1.54 ns/ft [ 5.05 ns/m ] velocity of propagation: 66% 66% note: unbalanced is measured between ground-signal-ground conductors, with shield grounded. balanced is measured between signal conductors within a pair, with the shield foating. environmental temperature rating: usa: cl2: 75c max canada: 80c flammability rating: usa: n.e.c. 725, cl2 canada: ft1 ul file no.: e118773, power limited circuit cable; cl2
3 interconnect solutions http://www.3m.com/interconnects/ 3m is a trademark of 3m company. for technical, sales or ordering information call 800-225-5373 3m ? round, shielded/jacketed, disc. wire cable 28 awg stranded, twisted pair, po/pvc 3644x series ts-0826-b sheet 2 of 3 inch [mm] tolerance unless noted .0 .00 .000 inch .1 .05 .010 [ ] dimensions for reference only c d i m a . 026 mi n [ 0 . 66 ] pv c j a ck et bra i d fille r (m f g r o p t i on ) ca b l e : twist e d pai r film foi l foam p o ly p ropyl e ne t a p e discrete w i r e detai l . 02 6 . 00 1 [ 0 . 66 ] foam po l y p ropyle n e t a p e film f o i l 2 8 a w g 7 3 6 [ 7 0 . 127 ] t in n ed s t rand e d c o ppe r con d uc t o r s number of conductors 3m part number dimension a .02 14 (7 pair) 3644x/14 .22 [ 5.6 ] 16 (8 pair) 3644x/16 .23 [ 5.8 ] 20 (10 pair) 3644x/20 .24 [ 6.1 ] 24 (12 pair) 3644x/24 .25 [ 6.4 ] 26 (13 pair) 3644x/26 .25 [ 6.4 ] 30 (15 pair) 3644x/30 .27 [ 6.9 ] 36 (18 pair) 3644x/36 .29 [ 7.4 ] 40 (20 pair) 3644x/40 .30 [ 7.6 ] 50 (25 pair) 3644x/50 .32 [ 8.1 ] 68 (34 pair) 3644x/68 .37 [ 9.4 ] 80 (40 pair) 3644x/80 .39 [ 9.9 ] 100 (50 pair) 3644x/100 .44 [11.2 ]
3 interconnect solutions http://www.3m.com/interconnects/ 3m is a trademark of 3m company. for technical, sales or ordering information call 800-225-5373 3m ? round, shielded/jacketed, disc. wire cable 28 awg stranded, twisted pair, po/pvc 3644x series ts-0826-b sheet 3 of 3 ordering information 3644x / xx xx note: standard length 20 through 68 conductors is 300 feet per roll. standard length of 80 and 100 conductor cables is 200 feet per roll. pair identifcation pair cond 1st conductor cond 2nd conductor solid band solid band 1 1 white tan 2 tan white 2 3 white brown 4 brown white 3 5 white pink 6 pink white 4 7 white orange 8 orange white 5 9 white yellow 10 yellow white 6 11 white green 12 green white 7 13 white blue 14 blue white 8 15 white violet 16 violet white 9 17 white gray 18 gray white 10 19 tan brown 20 brown tan 11 21 tan pink 22 pink tan 12 23 tan orange 24 orange tan 13 25 tan yellow 26 yellow tan 14 27 tan green 28 green tan 15 29 tan blue 30 blue tan 16 31 tan violet 32 violet tan 17 33 tan gray 34 gray tan 18 35 brown pink 36 pink brown 19 37 brown orange 38 orange brown 20 39 brown yellow 40 yellow brown 21 41 brown green 42 green brown 22 43 brown blue 44 blue brown 23 45 brown violet 46 violet brown 24 47 brown gray 48 gray brown 25 49 pink orange 50 orange pink 26 51 pink yellow 52 yellow pink 27 53 pink green 54 green pink 28 55 pink blue 56 blue pink 29 57 pink violet 58 violet pink 30 59 pink gray 60 gray pink 31 61 orange yellow 62 yellow orange 32 63 orange green 64 green orange 33 65 orange blue 66 blue orange 34 67 orange violet 68 violet orange 35 69 orange gray 70 gray orange 36 71 yellow green 72 green yellow 37 73 yellow blue 74 blue yellow 38 75 yellow violet 76 violet yellow 39 77 yellow gray 78 gray yellow 40 79 green blue 80 blue green 41 81 green violet 82 violet green 42 83 green gray 84 gray green 43 85 blue violet 86 violet blue 44 87 blue gray 88 gray blue 45 89 violet gray 90 gray violet 46 91 white - 92 tan - 47 93 gray - 94 brown - 48 95 blue - 96 pink - 49 97 violet - 98 orange - 50 99 green - 100 yellow - number of conductors (see table) jacket color options: a = "special" black jacket b = "standard" beige jacket blank = standard sf = splice free
regulatory information appendix 3m electronic solutions division/interconnect europe appendix e1: european union rohs directive 2002/95/ec, restriction of the use of certain hazardous substances in electrical & electronic equipment, as amended by eu commission decision 2005/618/ec. this product is rohs compliant 2005/95/ec. rohs compliant 2005/95/ec means that the product or part (product) does not contain any of the substances in excess of the maximum concentration values in eu directive 2002/95/ec, as amended by commission decision 2005/618/ec, unless the substance is in an application that is exempt under eu rohs. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. appendix e2: european union rohs directive 2002/95/ec, restriction of the use of certain hazardous substances in electrical & electronic equipment, as amended by eu commission decision 2005/618/ec. this product contains lead in the compliant pin area in excess of the maximum concentration value allowed but is compliant by exemption under eu commission decision 2005/747/ec. rohs compliant 2005/95/ec means that the product or part (product) does not contain any of the substances in excess of the maximum concentration values in eu directive 2002/95/ec, as amended by commission decision 2005/618/ec, unless the substance is in an application that is exempt under eu rohs. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. appendix e3: european union rohs directive 2002/95/ec, restriction of the use of certain hazardous substances in electrical & electronic equipment as amended by commission decision 2005/618/ec. this product contains lead in the solder tail area in excess of the maximum concentration value allowed . unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. appendix e4: european union rohs directive 2002/95/ec, restriction of the use of certain hazardous substances in electrical & electronic equipment, as amended by eu commission decision 2005/618/ec, as amended by eu commission decision 2005/717/ec, as amended by eu court of justice decision 2008/c 116/04 this product contains decabde in the insulating material in excess of the maximum concentration allowed for fnished products subject to eu rohs that are placed on the eu market after june 30, 2008. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. ria-2217b-e
appendix e5: european union rohs directive 2002/95/ec, restriction of the use of certain hazardous substances in electrical and electronic equipment, as amended by eu commission decision 2005/618/ec. this product contains lead in excess of the maximum concentration value allowed but is compliant by exemption under item 6 of the annex to the directive. rohs compliant 2005/95/ec means that the product or part (product) does not contain any of the substances in excess of the maximum concentration values in eu directive 2002/95/ec, as amended by commission decision 2005/618/ec, unless the substance is in an application that is exempt under eu rohs. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. china appendix c1: china rohs electronic industry standard of the peoples republic of china, sj/t11363-2006, requirements for concentration limits for certain hazardous substances in electronic information products. this symbol, per marking for the control of pollution caused by electronic information products, sj/t11364-2006, means that the product or part does not contain any of the following substances in excess of the following maximum concentration values in any homogeneous material: (a) 0.1% (by weight) for lead, mercury, hexavalent chromium, polybrominated biphenyls or polybrominated diphenyl ethers (excluding decabde); or (b) 0.01% (by weight) for cadmium. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the warranty stated below. appendix c2: china rohs electronic industry standard of the peoples republic of china, sj/t11363-2006, requirements for concentration limits for certain hazardous substances in electronic information products. this symbol, per marking for the control of pollution caused by electronic information products, sj/t11364-2006, means that the product or part does contain a substance, as detailed in the chart below, in excess of the following maximum concentration values in any homogeneous material: (a) 0.1% (by weight) for lead, mercury, hexavalent chromium, polybrominated biphenyls or polybrominated diphenyl ethers (excluding decabde); or (b) 0.01% (by weight) for cadmium. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. the numerical reference in the symbol above should not be construed as a representation regarding the products life or an extension of a product warranty. the product warranty is stated below. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the product warranty stated below. ria-2217b-e
important notice all statements, technical information, and recommendations related to 3ms products are based on information believed to be reliable, but the accuracy or completeness is not guaranteed. before using this product, you must evaluate it and determine if it is suitable for your intended application. you assume all risks and liability associated with such use. any statements related to the product which are not contained in 3ms current publications, or any contrary statements contained on your purchase order shall have no force or effect unless expressly agreed upon, in writing, by an authorized offcer of 3m. warranty; limited remedy; limited liability. this product will be free from defects in material and manufacture for a period of one (1) year from the time of purchase. 3m makes no other warranties including, but not limited to, any implied warranty of merchantability or fitness for a particular purpose. if this product is defective within the warranty period stated above, your exclusive remedy shall be, at 3ms option, to replace or repair the 3m product or refund the purchase price of the 3m product. except where prohibited by law, 3m will not be liable for any indirect, special, incidental or consequential loss or damage arising from this 3m product, regardless of the legal theory asserted. please recycle. printed in usa. ? 3m 2008. all rights reserved. ria-2217b-e 3 3m electronics solutions division 6801 river place blvd. austin, tx 78726-9000 u.s.a. 1-800-225-5373 www.3m.com/interconnects 3m is a trademark of 3m company. appendix c3: china rohs electronic industry standard of the peoples republic of china, sj/t11363-2006, requirements for concentration limits for certain hazardous substances in electronic information products. this symbol, per marking for the control of pollution caused by electronic information products, sj/t11364-2006, means that the product or part does contain a substance, as detailed in the chart below, in excess of the following maximum concentration values in any homogeneous material: (a) 0.1% (by weight) for lead, mercury, hexavalent chromium, polybrominated biphenyls or polybrominated diphenyl ethers (excluding decabde); or (b) 0.01% (by weight) for cadmium. unless otherwise stated by 3m in writing, this information represents 3ms best knowledge and belief based upon information provided by third party suppliers to 3m. the numerical reference in the symbol above should not be construed as a representation regarding the products life or an extension of a product warranty. the product warranty is stated below. in the event any product is proven not to conform with 3ms regulatory information appendix, then 3ms entire liability and buyers exclusive remedy will be in accordance with the product warranty stated below.
|
